Recent content by dem1000

oil level?

Try to start with key.

It should be 500km.

My setup for 2020 MTX 153, 240-270-300 Hurricane SS Thunder Products Heavy Hitters @79gr Drive Spring Thunder Products Orange Driven Spring Thunder Products Orange @3-2 Dalton 39/33 Helix So far this works at 50 km without any problems with the belt.

In Sweden.

No.

Should it fit better with steep helix?

I put the secondary at 40 (3 + 1) and the belt did not go off, but broke down on one side when I drove in deep snow. It got a little lazy at low speeds. I put an 8JP and took away 3/4 weight in heel and now it works very well. I'm considering setting a steeper helix and turning up to 50?

It was a bigger difference than I expected. Up to 6000 rpm, it was as normal, but after that it became much stronger. Otherwise it was completely stock. Much more fun than stock tune.

I think that when I drive slowly and hit the gas and the boost increases, the secondary does not shift fast enough due to strong spring or too little angle on the helix. Then it pulls the belt straight off. It happened to me both on hard trail and in deep snow. (Hurricane 270 r)

I think that when I drive slowly and hit the gas and the boost increases, the secondary does not shift fast enough due to strong spring or too little angle on the helix. Then it pulls the belt straight off. It happened to me both on hard trail and in deep snow.

What do you say about removing weight in the heel when turning the secondary less?

I drove today with 270r tp big venom with oranrge spring and 35 helix sat at 3 and 1 with gates carbon in powder snow and it worked well. Not as snappy as 3 and 3 though.

Last year I drove Hurricane 225 flash, otherwise standard. Drove 2650 km (1650 mile) with 8jp, no problem. This year I drive Hurricane 270 race with Thunder Products Big Venom kit and Orange Secondary set at 3,3. Running 6 km (4 mile) the belt went straight of, put on a used belt that lasted 100...

At the end of the season I put a little more weight in the middle of the clutch arm, and it got a bit better. This season i am going to run 270-280 and thunder products clutch kit.